Survey by Qualaroo
+ Reply to Thread
Page 49 of 125 FirstFirst ... 3947484950515999 ... LastLast
Results 961 to 980 of 2484
Like Tree346Likes

Thread: Mehran Experience Tips and suggestions

  1. #1
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Cool Mehran Experience Tips and suggestions

    AOA
    i have owned mehran for 7 years almost and most of the stuff has gone wrong so if some one has an issue with mehran he can ask me here i will be glad to help a mehran brother to put him out of this misery as mehran is a car that can make u go mad and pull ur hair a part KIDDING
    so some one has problem post it here i will do my best to come up with a solution
    Problem no 1: Starting in winters is a hell if ur getting late dhicka will do the trick but u need to check few things Park the car in night on petrol,Open the Self as mechs call it SULF and check barrings in it they are copper barrings and if needed so replace them else ask the electrification to clean the self,and reinstall it
    then check the battery DON'T add water over the High level mark as in winters problems is that Engine OIl freezes or gets thick and it needs extra kick from the battery
    other things related are clean the plugs and change the plug wires possible to 8mm ones and clean or replace the Point which comes in Distributor
    also check the
    +ve wire of the self is Tight to battery as most of the time its a small thing which makes u go mad

    PRoblem no 2
    :
    Axel and CV joints so CV joints are too weak in mehran and 3 years of rough driving can kill them and when replacing CV joints never go for a kabuli AXEL as they tend to be repaired most of them use Chinese ones they work good and tell the Kharaiya to never temper with the length of the Axel in fitting of the Cv joints the length should be as OEM specs
    and if the Straight joint is worn out replace it with Cross and the Cross kupa but be careful for length and the kuppa pick the kuppa which has the smoothest end which goes in to the Gearbox as it can damage Axel seals in gear box
    always use the Original Rod of ur car as its build for ur car a mechanic will suggest u to replace whole AXEL with Kabuli but its from an older model besides most of them are repaired
    Issue in top speed and pick
    when i first got the chance to Floor mehran on M1 with iridium plugs and 8mm wires bought from Shoba i was really Disappointed with results car was hitting 110km/h MAX on petrol i was so mad but in this i noticed a few things which were wrong in my car
    1 Cv joint of right axel
    2 Cylinder Packing it made dar dar sound like old taxies after 80Km/h mark
    3 and wires from shoba had no life in them they were used and abuses
    so excpet for CV joint i changed wires to new 8mm which are cheaper then shoba wali Kabuli wires and Cylinder Packing plus whole exhaust had wholes so repaired it all got her tuned from ENERCON center and after a few days i hit the M1 again plus similar iridiums were in it and this time results were amazing mehran ha 165/70/12 tires and speedo was showing 130 so u can guess what it was in real speed as big tires cause speedo to give an error 100 in speedo = 112.2 Km/h in real

    Ignition Coil replacement


    as most of mehrans have OIL ignition coil which Comes FF and it sucks it has a limited life and mechs do make a mistake when coil dies they assume that head gasket is gone and which leads to other problems.replace coil with magnetic coil which Alto and Cultus use its way better and gives an edge in starting costs were low when i did this 600 for the coil brand new but now i herd its for 1500 or something comes in a triangle box.

    Front Guarder o
    r GADRI

    as time passes Front Guarder or GADRI become rusted and weak which causes problems for mountings of the front jumping rod a new Front Guarder or GADRI is about 1000 and 4 bolts hold it in place on a non accidented car its not a big job Front bumper needs to be opened and jumping rod and 4 bolts and its the reverse process while fitting but a car which had some accident then its a job in which a denter makes some $$$$ but there is always a way around intall gaudri and all stuff and see if there is some difference on alingment of bolts of front engine mounts cut a whole with welding torch in the engine mounting plate and its easy and also make adjustments to the jumping rod u can make tires placement in the wheels where they will fit but go for some good dentor so frame can be pulled out will cost more but its the right way
    installation of Foam in Doors to reduce sounds
    its a simple task install some pieces of foam behind the lock wires and door handle wires inside the door
    open the inner door covers first take the hadle out its held with 2 screws then take the cover of handle out held with single screw then the window winder take it out but it requires a trick rool it to a point u can see the joint end of the pit take it out with a screw driver and window winder will be free
    then take the cover our its held with clips but don't put much pressure on them they can break after its out check all bolts and screws inside the doors if they are loose tight them and hit the door with ur fist so u can hear sounds now with other hand start detecting what wire is loose cut some foam and put it between the door and line
    by this u can reduce 90% of sounds in mehran
    Tire and rim size
    now we see many Kewl boys put 15s on a mehran but this little car never needs huge wheels
    best size for mehroo is 145/70/12 and 155/70/12 no other these two are best sizes


    Mehran Experience Tips and suggestions -414980

    Hanjiii Kaa Storeey Eehh !

  2. #961
    PakWheeler Follow
    faizanali's Avatar
    Join Date
    Jan 2007
    Location
    Lahore
    Age
    35
    Posts
    782
    Follows
    0
    Following
    0
    Mentioned
    11 Post(s)
    Tagged
    1 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    1

    Default

    Quote Originally Posted by ekdrifter View Post
    3 nali radiator if u face issues other wise cleaning of rad and always use only coolant 3 bootles of zic

    Sent from my A10 using PW Forums mobile app
    3 bottles of coolant? mean 1 ltr x 3 ???

  3. #962
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by faizanali View Post
    3 bottles of coolant? mean 1 ltr x 3 ???
    yes but buy from trusted place and i found zic coolant best
    Hanjiii Kaa Storeey Eehh !

  4. #963
    PakWheeler Follow
    muhammad.hamza.shahid's Avatar
    Join Date
    Oct 2013
    Location
    Karachi
    Age
    23
    Posts
    72
    Follows
    0
    Following
    0
    Mentioned
    1 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    salam guyz, any one can guide me why car is giving a bump on low speed? it moves in a vibrating manner olf left and right, i had installed yokohama new and perfectly good tyres like 2,3 months ago, and i dont think it is because of tyres, can it be because of axle replacement i did from shahjee?

  5. #964
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by muhammad.hamza.shahid View Post
    salam guyz, any one can guide me why car is giving a bump on low speed? it moves in a vibrating manner olf left and right, i had installed yokohama new and perfectly good tyres like 2,3 months ago, and i dont think it is because of tyres, can it be because of axle replacement i did from shahjee?
    could be axel replacement needs alignment
    Hanjiii Kaa Storeey Eehh !

  6. #965
    PakWheeler Follow
    bimmer123's Avatar
    Join Date
    Feb 2014
    Location
    Rawalpindi
    Posts
    8
    Follows
    0
    Following
    0
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    AoA,
    This is a great thread for people like me. I got a 2004 mehran in april last year. I am a student and this is my first car. I started taking it to university from sep 2013. I have a few concerns about its performance. I hope you guys can help out

    1. recently when I accelerate while making a turn, there is tk tk tk sound from the front left side. What is it?
    2. For about 6 months I have been hearing kr kr krrr sound inside the cabin. I though it is the relay that is connected beside steering but it is not the relay.
    3. the temperature gauge is always below C
    4. While shifting to 1st gear I often find it difficult to engage it. Then I have to lift the clutch a little till I hear a slight grinding sound, the press the clutch and put into first.
    5. The car never goes above 80kmph on CNG

    I am new to this car keeping thingy so, don't know much. Please help and mention the local mechanic names of parts so that I may be able to tell the mechanic. They don't get terms like struts etc.

  7. #966
    R.I.P. Follow
    shegg4's Avatar
    Join Date
    Mar 2013
    Location
    Select City
    Posts
    705
    Follows
    1
    Following
    0
    Mentioned
    123 Post(s)
    Tagged
    9 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by bimmer123 View Post
    AoA,
    This is a great thread for people like me. I got a 2004 mehran in april last year. I am a student and this is my first car. I started taking it to university from sep 2013. I have a few concerns about its performance. I hope you guys can help out

    1. recently when I accelerate while making a turn, there is tk tk tk sound from the front left side. What is it?
    2. For about 6 months I have been hearing kr kr krrr sound inside the cabin. I though it is the relay that is connected beside steering but it is not the relay.
    3. the temperature gauge is always below C
    4. While shifting to 1st gear I often find it difficult to engage it. Then I have to lift the clutch a little till I hear a slight grinding sound, the press the clutch and put into first.
    5. The car never goes above 80kmph on CNG

    I am new to this car keeping thingy so, don't know much. Please help and mention the local mechanic names of parts so that I may be able to tell the mechanic. They don't get terms like struts etc.
    1 : in your axels check them from any good machenic.
    2 : if it;s inside cabin kr krr krrr than there must be something loosen inside your dash do check it but if it;s from engine compartment then this could be your front suspenssion or it can be speedo meter cable.
    3 : your temp gauge wire isn't fitted properly do check it.
    4 & 5 : pressure and clutch plates needs to be change and also check gear oil and change it .

  8. #967
    R.I.P. Follow
    shegg4's Avatar
    Join Date
    Mar 2013
    Location
    Select City
    Posts
    705
    Follows
    1
    Following
    0
    Mentioned
    123 Post(s)
    Tagged
    9 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by muhammad.hamza.shahid View Post
    salam guyz, any one can guide me why car is giving a bump on low speed? it moves in a vibrating manner olf left and right, i had installed yokohama new and perfectly good tyres like 2,3 months ago, and i dont think it is because of tyres, can it be because of axle replacement i did from shahjee?
    Yes this is axel fault. normally axels k size me fark hota hay tabhi gari ki chaal badal jati hay ...

  9. #968
    PakWheeler Follow
    bimmer123's Avatar
    Join Date
    Feb 2014
    Location
    Rawalpindi
    Posts
    8
    Follows
    0
    Following
    0
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by shegg4 View Post
    1 : in your axels check them from any good machenic.
    2 : if it;s inside cabin kr krr krrr than there must be something loosen inside your dash do check it but if it;s from engine compartment then this could be your front suspenssion or it can be speedo meter cable.
    3 : your temp gauge wire isn't fitted properly do check it.
    4 & 5 : pressure and clutch plates needs to be change and also check gear oil and change it .
    Thanks for the reply, I'll get these checked asap. Does anyone know how much would the whole wiring of mehran 2004 cost me? and also the method to check the gear oil?

  10. #969
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by bimmer123 View Post
    AoA,
    This is a great thread for people like me. I got a 2004 mehran in april last year. I am a student and this is my first car. I started taking it to university from sep 2013. I have a few concerns about its performance. I hope you guys can help out

    1. recently when I accelerate while making a turn, there is tk tk tk sound from the front left side. What is it?
    2. For about 6 months I have been hearing kr kr krrr sound inside the cabin. I though it is the relay that is connected beside steering but it is not the relay.
    3. the temperature gauge is always below C
    4. While shifting to 1st gear I often find it difficult to engage it. Then I have to lift the clutch a little till I hear a slight grinding sound, the press the clutch and put into first.
    5. The car never goes above 80kmph on CNG

    I am new to this car keeping thingy so, don't know much. Please help and mention the local mechanic names of parts so that I may be able to tell the mechanic. They don't get terms like struts etc.
    answers
    1 both CV joints need replacement cost 2200 for good china ones with 1 year warranty
    2 check dash board and sound could be from doors
    3 ur Rad fan is Direct get it checked that it has thermostate valve or not if not then get one installed Drain all the water in Rad use 3 botttles of coolant Zic green bottles and get fan auto
    4 ur cluch cable needs adjustment or replacement good one is for 700rs
    5 ur car might be needing tappets tuning and plugs replacement even plug wires need to be replaced
    Hanjiii Kaa Storeey Eehh !

  11. #970
    PakWheeler Follow
    aftab371's Avatar
    Join Date
    May 2005
    Location
    Lahore
    Age
    37
    Posts
    67
    Follows
    0
    Following
    1
    Mentioned
    1 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    aoa everyone,

    Great thread! What is the stock tyre size for Mehran?
    Suzuki Mehran I Suzuki Marauder GZ250 I Honda CG125

  12. #971
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by aftab371 View Post
    aoa everyone,

    Great thread! What is the stock tyre size for Mehran?
    145 70 12
    Hanjiii Kaa Storeey Eehh !

  13. #972
    PakWheeler Follow
    bimmer123's Avatar
    Join Date
    Feb 2014
    Location
    Rawalpindi
    Posts
    8
    Follows
    0
    Following
    0
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    AoA,
    today I went to the mechanic and got the car checked. He adjusted the tappets and now the pick is good. He also told me that the car needs replacement of front and rear shock absorbers and also the adjustment of leaf springs.
    Please tell me which shock absorbers would be best and from where can I get these and price as well.
    Mechanic said the original front would be 6000 rupees pair.
    Kindly guide.

  14. #973
    PakWheeler Follow
    aftab371's Avatar
    Join Date
    May 2005
    Location
    Lahore
    Age
    37
    Posts
    67
    Follows
    0
    Following
    1
    Mentioned
    1 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by ekdrifter View Post
    145 70 12
    So when you said,
    ".......165/70/12 tires and speedo was showing 130 so u can guess what it was in real speed as big tires cause speedo to give an error 100 in speedo = 112.2 Km/h in real"

    I couldn't understand. When you had 12" diameter tyres then speed should be exactly whats on the speedo. Please explain. As I understand diameter effects actual and speedo readings. What do you think?

    Thanks.
    Suzuki Mehran I Suzuki Marauder GZ250 I Honda CG125

  15. #974
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by aftab371 View Post
    So when you said,
    ".......165/70/12 tires and speedo was showing 130 so u can guess what it was in real speed as big tires cause speedo to give an error 100 in speedo = 112.2 Km/h in real"

    I couldn't understand. When you had 12" diameter tyres then speed should be exactly whats on the speedo. Please explain. As I understand diameter effects actual and speedo readings. What do you think?

    Thanks.
    there aspect ratio is different side wall is little higher then stock size u can check it on online tire size calculator it will give u all answeers
    Hanjiii Kaa Storeey Eehh !

  16. #975
    PakWheeler Follow
    burnoutrevenge's Avatar
    Join Date
    Mar 2012
    Location
    Karachi
    Posts
    193
    Follows
    0
    Following
    0
    Mentioned
    10 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    @ekdrifter bhai, which plugs should be preferred in mehran or cuore? Someone said platinum plugs have an edge over iridium in small carby cars like mehran alto cuore? Is it true? If yes then which brand should I prefer? For both mehran and cuore. Also, would adding silicon plug wires improve the overall performance?

    Sent from my A8 using PW Forums mobile app

  17. #976
    PakWheeler Follow
    bimmer123's Avatar
    Join Date
    Feb 2014
    Location
    Rawalpindi
    Posts
    8
    Follows
    0
    Following
    0
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    GUYS?

    AoA,
    today I went to the mechanic and got the car checked. He adjusted the tappets and now the pick is good. He also told me that the car needs replacement of front and rear shock absorbers and also the adjustment of leaf springs.
    Please tell me which shock absorbers would be best and from where can I get these and price as well.
    Mechanic said the original front would be 6000 rupees pair.
    Kindly guide.

  18. #977
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by burnoutrevenge View Post
    @ekdrifter bhai, which plugs should be preferred in mehran or cuore? Someone said platinum plugs have an edge over iridium in small carby cars like mehran alto cuore? Is it true? If yes then which brand should I prefer? For both mehran and cuore. Also, would adding silicon plug wires improve the overall performance?

    Sent from my A8 using PW Forums mobile app
    irididums are better then platinum in all aspects
    i used NGK iridium IX and Denso VK 20 both work in mehran and i think same for coure
    Hanjiii Kaa Storeey Eehh !

  19. #978
    Senior PakWheeler Follow
    dr3vil's Avatar
    Join Date
    May 2009
    Posts
    11,929
    Follows
    11
    Following
    0
    Mentioned
    201 Post(s)
    Tagged
    7 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Quote Originally Posted by bimmer123 View Post
    GUYS?

    AoA,
    today I went to the mechanic and got the car checked. He adjusted the tappets and now the pick is good. He also told me that the car needs replacement of front and rear shock absorbers and also the adjustment of leaf springs.
    Please tell me which shock absorbers would be best and from where can I get these and price as well.
    Mechanic said the original front would be 6000 rupees pair.
    Kindly guide.
    in rawalpindi ?? well Sadar will be the place
    and if ur low on budget then go for kabuli shocks
    get only bottle rest spring will be from ur old shock
    cost around 1200 for set
    and in new ones gabrial and KYB both are good
    if ur car is newer model then buy new ones
    and rear kamanies for that u need to go to a kamani expert
    Hanjiii Kaa Storeey Eehh !

  20. #979
    Senior PakWheeler Follow
    getscorpion's Avatar
    Join Date
    May 2009
    Location
    Karachi
    Age
    33
    Posts
    2,699
    Follows
    0
    Following
    0
    Mentioned
    15 Post(s)
    Tagged
    2 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    talking about mehran shocks... is its rear kamanis can be any good and softer? my car seems very stiff on roads and on bumps i hear sounds inside cabins from dashboard and trunk...

    Sent from Mars using Telegraph
    Rise from the ashes,.....

  21. #980
    PakWheeler Follow
    4Soul's Avatar
    Join Date
    Oct 2010
    Location
    Islamabad
    Posts
    67
    Follows
    0
    Following
    0
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Problems Posted
    0
    Problems Solved
    0
    Best Answers
    0
    Good Answers
    0

    Default

    Hi.
    Any body know where to buy air filter of Mehran Euro 2 . The genuine is for 1700

+ Reply to Thread
Page 49 of 125 FirstFirst ... 3947484950515999 ... LastLast

User Tag List

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •