Ask Xulfiqar - An Automotive Encyclopedia

[dayrider]

Which vehicle is it

[anon36782927]

This post was flagged by the community and is temporarily hidden.

[brownrose78]

@dayrider
If u r asking me, then its Kbyber

BTW I also need good dashboard repairer

[dayrider]

@omersiddiqui5482 someone from your city with a similar car needs your guidance

[omersiddiqui5482]

@dayrider sir i am all ears whats the issue!

@brownrose78 bhai i mentioned some numbers and shop in the personal message do check them out for you Speedo Issues

and yes Haji Sb. at Magazine Lane Plaza is a real good in repairing meter but it is better to get the wiring checked first.

also if you can share the pics of your Dashboard it will help us to asses the situation better!

[anon36782927]

This post was flagged by the community and is temporarily hidden.

[brownrose78]

Jazak Allah @omersiddiqui5482 bhai,
I went to Mani at Sagheer centre market, he checked and told that In cluster meter, 3 meters out of 4 are not working plus their back light is also not glowing so he will take 2,000 as Labor charges plus if there will be any parts then this will be upon me.
I agreed and it took almost 3 to 4 hours to him in sorting same meter.
Now all meter is working. Some parts were replaced too which total costed me around 2,000 like reverse light switch, wiring for cluster meter, gear-speedometer cable rotator lever, brake light switch, temperature sensor, 1 bulb of back light etc.
In the end he took 2300 Labor(instead of 2,000) as he told that horn was not working because of sone relay so he put relay from his side(i went for sometime and he did this in my absence)

So you can say that total 4,300 were spent but now cluster meter is working fine and showing correct readings of petrol level, temperature, speedometer, hand brake status light + reverse light issue also sorted(which always used to glow on start)

[omersiddiqui5482]

[zakiuddin]

This question is for @Xulfiqar but anybody is welcome to answer it.
The car is throwing intermittent P083B code which refers to "Fluid Pressure Sensor G circuit range/performance"(still no idea what a G circuit is). Its a 62TE chrysler transmission. I've narrowed it down to the LC pressure switch. I'm planning to replace the LC pressure switch without removing the valve body. I've got conflicting information here which i need to verify.
one bit of info tells me that i need to remove the valve body to remove solenoid pack for replacement as the solenoid pack is bolted from underneath but i'm not replacing the pack, i just wanna rebuild it. Which i believe is possible if i just remove the top metal plate with 6xT20/25 Torx bolts and then remove the plastic housing leaving out the metallic section of solenoid pack attached to valve body. This should give me access to LC pressure switch.
Is it correct or it's not possible unless i remove the valve body?

[Xulfiqar]

This is a real can of worms you have, and i bet its an intermittent fault too, the ultradrive 6 spds are a real pain to solve,

Firstly make sure there is no electric noise on the bus and make sure you dont have any other codes like loss of prime etc. (Or you might chase your tail)

The solenoid pack is usually an exchange item at transmission builders shops, ask around for a good price, it is rebuildable but in experience, its better to swap it whole.

I would not recommend half tearing the pack in place, remove it and redo it and yes it means removing the valve body on the ultradrive 6 spd.

There is a small dyno test for the sol pack, but requires chrysler software and some specific hardware to simulate.

This happens quite a lot on tc, caravans and pacifica too, being chrysler.. the repairs are very oddball. Some even are just a bad igntion key module.

[zakiuddin]

This is a real can of worms you have

Did i mention that i'm replacing the neutral safety switch in the same go??

make sure you dont have any other codes like loss of prime

Checked. I now have an Autel DS808 so no chance i'm missing on anything.

The solenoid pack is usually an exchange item at transmission builders shops, ask around for a good price, it is rebuildable but in experience, its better to swap it whole

Dealer is quoting 525$ and rebuilds are available around 250$. I'll bite the bullet if my rebuild fails. It doesn't have too many miles on it so the rest of the pack should be in good condition.

There is a small dyno test for the sol pack, but requires chrysler software and some specific hardware to simulate.

Yea some kinda "Transmission Simulation Tool".

This happens quite a lot on tc, caravans and pacifica too, being chrysler.. the repairs are very oddball. Some even are just a bad igntion key module.

The problem is intermittent and i've been watching it for over 3 months now.. I'm pretty sure that either the diaphram in the LC pressure switch is cracked or the brass contact is playing up. I ordered these two parts from a Sonnax dealer to use in the rebuild. I'll keep you posted.

[pwuser157504886650]

bro plz read my plight as well

i will do that tnight and then share with u

[Xulfiqar]

Seems you are on right track.

Good luck.

[abdullahiqbal626]

Assalamu alikum
I am facing a issue in my civic 8th gen mt 2012 model when i release clutch in 1st gear car shudders/vibrates for a sec its perfectly fine in other gears.

I faced this issue couple months ago but it only happened once or twice and it vanished after it but today i noticed it again its not happening on regular basis but it happens 5 out of 10 times but only in first gear

[flyingfeather]

Wa salam. Get the engine mounts checked

[ali01]

It mean ur clutch & pressure plates worn out and required to b changed

[usm01]

@Xulfiqar
changed timing belt and tensioner for indus cuore with oem parts 4months ago
mechanic aligned belt using his skills or marks (not sure).
car is driving ok.
anything to be concerned about in future about proper belt alignment.

[Xulfiqar]

all toyota engines have timing marks. He must have used them.

[usm01]

does daihatsu cuore engine (indus) also have timing marks.

[Xulfiqar]

Yes

Btw

Daihatsu is owned by toyota