Wrd Vitz

[turbolover]

Length of the intake pipe can effect the performance. Read this test on a charade.

http://autospeed.com/cms/A_107749/article.html

[wasay_ahmed]

yeah it does for sure but thts best fit for vitz as no other place I also bought shorth rame but insufficent place under the hood

[wasay_ahmed]

today got 3times bigger soundbox but with 2"m inlet

Results very sleek sound at topeend

[antiflag]

i have a question.. How do you know if you're car is running rich ? i mean does your rpm stays above 1000 ? or what, and cant u lower the rev from the engine but adjusting the screws ? Y did u have to change the fuel pump, as vitz's fuel pump hardly needs replacement. please help me understand. thanks

[wasay_ahmed]

@antiflag

frmg oing through my thread u will know basicly i changed two pumps.

first i replaced the 1 which came from Japan installed as it started hesitating at topend there was a jerk.Afterwards I bought this Japnese Pump which had too much flow and itb was Making car richer.How i figure this out Know.The Mileage was going down and making the plugs blackinsh and silencer aswelll The car was though.SOfinaly found the OE recomended Pump Brandnew and thow tht now its good good MashaAllah

[wasay_ahmed]

After alot of work etc finaly succefull in desiginging Bolt on typo Ram Air Intake Allhumdullilah

[wonder_guy]

Gud going.

[shirazkhan]

@ wasay
(Y) good job bro

can u guide me in getting a good air intake for my vitz
my air filter gets choked very quickly
& i feel vibration also, air intake increases fuel consumption & if difference is not much i will go for it

& hows ur MAF sensor , i hope its reading is not getting messed up by the air intake

[Storm]

WHOA!! you'e been very busy sice my last visit,.. but i must admit i admire your persistance for perfection. how's everything running now? what future plans?

[wasay_ahmed]

@shiraz

Jinab since i have installed all this stuff the fuel is better then b4 whn it use to be stock.2ndly the main reason for running after market intake is the Quality of Stock air filter which gets choked after 1000 1500kms as u said i only ran 1 filter n after this using Aftermkt its cost saving better response at the same time.Rest the car is stable no problems wth maf as now its already fitted in proper adapter use to behave well even wth JUGAR fitting

[wasay_ahmed]

@umer

Jazak Allah

@storm

Well the car has so far covered 27k kms Allhumdullilah n yet engine is performing even better.

Regarding plans will drive it drive it untill the stock engine dies.Was trying to get complete chrome but no buddy is ready to bend this 2.5" pipe.

[shirazkhan]

@ wasay

can we discuss this on msn
shiraz_0786@hotmail.com

[killervtec]

Good going buddy,
Nice DIY

[aabirgti]

Nice going i also tried it but wasnt workin for me i had a curved pipe going over but i had probs wit da maf sensor position i couldnt get it right n also at certain times the car would jus shut down so i took it off n scraped it.

[wasay_ahmed]

@abir

Well Alhumdullilah i never faced the shutting down problem etc though i was afraid of it all the time But now Allhudullailah After this proper fitting very very rare chances

[jz]

same here wassay,even when v did a diy on my car v never faced a single prb regarding the MAF Alhumdulillah,will do another diy on my car regarding the MAF adapter when eva i get some spare time

[jz]

the adapter v got made is running fit in my car as well
if any vitz/corolla owner wants an adapter can let us know via PM

[wasay_ahmed]

Today cleaned the Radiator external area Used Kangroo engine cleaner and NASA Carb cleaner.
First sprayed kangroo and Sprayed Water as recomeneded on the bottle.
For some further cleaneing used Carb cleaner and then again sprayed the water as Carb cleaner is a bit oily.SO to avoid dust Spraying wather was necessary results were good and hopefully this cleaning will be enough for this summer

Also did a Little experiment Washed Urethene Air Filter with JOHNSONs Babay shampoo lolz so far it looks good.Sumbuddy recomended to use surf but to me the particles of surf might block it further.
Though Washing it with petrol is also good option but Pressurized spray worth would try tht as well sumtime.

[wasay_ahmed]

Stay tunned sum updates on the way InshaAllah

[zaitron]

Keep it inside the car with you and turn on the AC. Coldest Cold Air Intake ever!