Generator Engine Overhauling & ATS Dedicated Thread ( Advice , DIY, Repair ,Install)

[hanimughal]

yup...
our model is the best one..
hows jlt working?all good?
btw guru on other thread of power generators..
check what this guy wrote:
i need some suggestion.
i have loncin 2.5 gen.yesterday i tried to run my 1 ton mitsu hvy duty ac on it and to my surprise it runs without giveing any big jhatka to generator.its consuming 1200 watts and genrtr runs fine.i runs ac for 1 hours on gen.gen was showing 200 volts out put during that.should i keep runing ac on generator or should i stop for sake of ac or genrtr??genrtr is on GAS.

and i asked him to make a video for me...
check this out...
06062012006.mp4 - YouTube

[MoizIrfan]

yes i have heard it also in other forum but i cannot believe it. locin can be that much powerful. (A)(A)

[MoizIrfan]

Can anyone tell me the power of a 1 horse power water motor in terms of Watts

[hanimughal]

746 watts equals to 1 horsepower not all horsepower ratings are same,the 746 watt figure is a direct conversion from reading power from one term of measurement to another...
u wanna run ur water pump via loncin? yes u can run easily

[MoizIrfan]

yes on gas

[afarooqi]

Thanks bro
I have checked with Elite Kits, they have one the same and selling it for Rs.5000/-

@moiz dont worry
INSHALLAH it will ...
show me the picture and i also wana see ur gsm door opener
hahaha..
@afarooqi
he got it from electronik 2000 lahore hall road..
well about karachi u can check out at
ELITE kit centre near regal chowk.

[hanimughal]

omg thats way too much then original price...
then make one urself..moiz lives in karachi too he can help you

[Sharo53]

Thanks bro
I have checked with Elite Kits, they have one the same and selling it for Rs.5000/-

sir if you have any relative or friend in lahore ask him to buy it from here and send it to you via TCS...this will be alot cheaper then 5000

[noumanzia]

Thanks bro
I have checked with Elite Kits, they have one the same and selling it for Rs.5000/-

u better call electronik 2000, they will send it to by courier with nominal charges.

[noumanzia]

post some detail pic of this circuit ,,,,,,,,,,12 volt tranforers are vacant,,,,,,,,,,,why ?........have you conform that from the shop where you purchase ? charger ALT 12 is not of battery or charging connection,,,,,,,,,if its for changing then where is the 6 to 10 Amp 12 volt transformer which charges the battery ?.............you batter conform all this from the shop and ask him to provide the circuit diagram,,,,,,,,,,,,,,
another thing,,,,,,,,,,,this circuit is lot different from the one which another guy already posted (i forget his made but he also share its movie),......,,,,,,,,,,,,,,,

well this kit is faulty as burnt during usage, i was trying to repair it. well the transformer i detached as i needed for my ats. still trying to figure out,replaced so burnt parts.
i have a problem relating generator output voltage.
it started to produce 300v with speed is higher than usual. Whenever we started it its on high speed relatively higher than previous on no load, then we put some load on it and its noise lessen with the load. few days, this thing kept on going. today i experienced that the voltage is dropped and came down to 180 volts, also generator was working like with very few load instead of the all appliances were working which normally work over generators. fans, tube lights , energy savers, two water cooler ( Lahori one), few tvs . Generator is Green power with 5 KVA.

Then I checked the AVR , it was some how deshapped from the center , and capacitor is also looking like over heated. so i replaced the AVR. after attaching it with generator, i adjusted the voltage with the tiny screw to 220v.

but the generator noise is still like its on low load, instead of all appliances were running . then i moved towards the speed adjustment screw , which was a the lowest level of speed setting , i cannot be able to decrease the speed from that.

what is the possible cause of speed enhancement?

ONE general question?
does the load causes the speed to up or down? like when we put more load, it communicates this to generator through governor and ultimately speed increases and stables the voltage?

[asimm76]

Anyone having any idea about TRICOM generator sets onf 2.5-6.0kva .. They claim that their genrators are factory fitted GAS runners and they dont ask you to run even 1 hour on petrol... no need at all... still no ring burns etc

[hanimughal]

bro here this thread starter agoodfriend
if you see his new generator.. on his first day he separated the fuel tank
and its running on natural gas from the same day..besides that his old generator of 2.5kwa before overhauling completed 2400hours and he separated its fuel tank aswell
and whole time 3years with homemade ats and on natural gas.. it did payoff ..

[ToxicDevil]

From a few days my generator on moderate load feels like its suffocating. Throttle is almost half to three quarter open on moderate load and on a little more load it gets full open and generator dies.
Without load even if I rev the generator to full throttle there is no problem.

What could be the reason?? I changed the spark plugs.

[faizanrao]

I plan to overhaul my generator myself so just wanted to know what numbers of spanners i would be needing?
Kindly tell me every number of spanner needed or any other equipment required.
I have a 8,10,12,14 number spanner available right now..
thanks in advance

[5555]

I plan to overhaul my generator myself so just wanted to know what numbers of spanners i would be needing?
Kindly tell me every number of spanner needed or any other equipment required.
I have a 8,10,12,14 number spanner available right now..
thanks in advance

just add 13 and 21 try to get t-rod of all these this helps a lot

[ToxicDevil]

From a few days my generator on moderate load feels like its suffocating. Throttle is almost half to three quarter open on moderate load and on a little more load it gets full open and generator dies.
Without load even if I rev the generator to full throttle there is no problem.

What could be the reason?? I changed the spark plugs.

Anyhelpplz

[hanimughal]

@toxicdevil
bro not really sure, agoodfriend can answer you ..
have u tried it on petrol? same situation?

[ToxicDevil]

It is factory fitted natural gas.

[Sharo53]

guys i want to know any one using 1.5ton split unit on generator?
whats to change in sound of generator?
when i turn ON 1.5ton ac on my 6.5Kva generator a sound like "gun fire" come from generator sound like a loud "THAA" lol is it norml?

and just right now when turned the ac ON generator sound like "THAA THA THA" and then its curcuit breaker tripped...

[hanimughal]

@toxic then i guess there might be some adjustment needed or service in that kit of urs